Epoxy Experts coats garage, basement and commercial floors across Surrey, from Cloverdale and Fleetwood garages to studios and units in Newton, Guildford and South Surrey. Flake garage floors run $6 to $8 per square foot installed, so most two car garages land between $2,400 and $4,800, and every garage floor carries a 15 year written warranty against peeling and delamination.
A Surrey job you can look at
Strong Pilates in Surrey needed a studio floor that was easy to clean and let the character of the concrete show through. The slab still carried old coatings, so we ground it with 30, 70 and 100 grit diamond segments to strip them and open the surface, patched the voids and cracks, and sealed the floor with two coats of water based epoxy in a gloss finish. A satin topcoat with anti slip additive can go on top where people are moving and exercising. The full write up, with photos, is on our Strong Pilates project page.
What it costs in Surrey
We charge the same rates in Surrey as everywhere else we work. Flake floors are $6 to $8 per square foot, solid colour floors are about $7 and metallic floors run $10 to $15, with diamond grinding included in every rate. A 400 to 600 square foot two car garage comes to $2,400 to $4,800 in flake. Crack repair, a moisture primer or removing an old coating are priced as separate lines after we see the slab, and our garage cost breakdown lists every size and system.
What Surrey slabs need before coating
Most failed garage floors we see in the Lower Mainland peeled because the slab was never ground or tested for moisture. We moisture test every slab before quoting, and where the readings are high we use a moisture tolerant primer so the coating stays bonded through a wet winter. For garages that take direct sun or hot tires we recommend a polyaspartic topcoat, which holds its colour and resists tire marking better than epoxy on its own.
Commercial floors in Surrey
Commercial, warehouse and food plant floors are quoted per project after a site visit, because slab condition, drainage and your operating hours all change the scope. Commercial floors carry a 3 year written warranty. The systems we install for each sector are listed on our industries page.
Frequently asked questions
How much does an epoxy garage floor cost in Surrey?
A flake floor costs $6 to $8 per square foot installed, which puts a typical two car garage between $2,400 and $4,800. Solid colour is about $7 per square foot and metallic runs $10 to $15.
How long before I can park on a new floor?
You can walk on a new floor after about a day and park on it after five to seven days, once the coating has cured enough to take hot tires.
What does the warranty cover?
Garage floors carry a 15 year written warranty against peeling and delamination, metallic floors carry 5 years and commercial floors carry 3 years. The warranty applies to the original purchaser once the job is paid in full, and it does not cover cracks in the concrete, moisture coming up from the slab or chemical damage.
How do I get a quote for my Surrey floor?
Call (778) 653-8356 and we will book a free visit to measure the space, test the slab and give you a fixed written price before any work is booked.